Onboard Systems for RVs, Vans and Fleet Vehicles Near Whittier
Everything that runs when the coach is parked. Power, LP, climate, water and appliances, diagnosed in shop with the vehicle on shore power and a full tank. OCRV Center covers 23 distinct scopes inside this program, all performed in shop at the Yorba Linda facility. Owners across Whittier and Los Angeles County reach it on the I-605 and SR-72.
23 pages
Every scope in this program
- House Battery Replacement
Lead acid to lithium conversions, bank rebuilds, and the charge profile that has to change with them.
- Inverter and Charger
Inverter, charger and combined unit replacement, including transfer behaviour under load.
- Generator Service
Onan and Cummins generator service, load testing, and the mount and exhaust around them.
- Transfer Switch and Shore Power
Automatic transfer switches, shore cords, inlets and pedestals feeding them.
- Solar Installation
Panel, controller and wiring installation with roof penetrations sealed into the membrane properly.
- Antenna and Starlink Install
Roof mounted antenna and satellite internet hardware, mounted and sealed.
- Camera Installation
Backup and side camera systems wired to an in dash or standalone display.
- LP System Service
Regulators, lines, fittings and pressure testing across the propane system.
- Detector Replacement
LP, carbon monoxide and smoke detectors replaced on the expiry date stamped on the unit.
- Furnace Service
Forced air furnace diagnosis, sail switch, board and burner service.
- Water Heater Service
Tank and tankless units, anode, board, element and bypass valve work.
- Hydronic Heat Service
Aqua Hot and Oasis style hydronic systems, burners, pumps and zone loops.
- Air Conditioner Replacement
Rooftop and basement air units replaced, with the roof opening resealed to membrane spec.
- Ventilation Repair
Fans, ducting and range hood venting through the wall or roof.
- Refrigerator Service
Absorption and compressor refrigerators, cooling units, boards and the vent stack behind them.
- Cooktop and Microwave
Cooktop, oven and microwave replacement, including the LP and power feeds.
- Washer and Dryer Install
Stacked and combo units fitted with drain, supply and vent routed correctly.
- Fresh Water Plumbing
PEX and fitting repair, pump replacement, and pressure testing of the whole fresh side.
- Black and Gray Tank Repair
Tank cracks, valves, flanges and sensor systems, including tank removal where the flange is inaccessible.
- Macerator Pump
Macerator replacement and the discharge plumbing that feeds it.
- Toilet Replacement
Gravity, macerating and cassette toilets, with the floor flange checked for rot.
- Shower Pan Replacement
Cracked pans replaced and the subfloor beneath evaluated before the new pan is bedded.
- Faucet and Fixture
Interior and exterior faucets, shower valves and city water inlets.
Published rate card
What this costs
Bands are the working range for this scope at OCRV Center, not a quote. Body and paint labor bills at $210 per hour and mechanical at $260. The exact figure comes from the priced evaluation, which is credited against an authorized repair.
In shop process
How the job actually runs
- Step 01
Get the vehicle to Yorba Linda
Drive or tow the vehicle to 23281 La Palma Ave, Yorba Linda. Insurance walk ins are welcome and no appointment is needed to start a collision teardown.
- Step 02
Priced evaluation
Collision teardown is one hour at $210, an RV systems evaluation is $150, and an in depth diagnostic is one hour at $285. Every one of those is credited against an authorized repair, so the evaluation is not money you lose.
- Step 03
Scope and carrier
You get the scope in writing with rate card figures against it. If a carrier is involved the shop bills direct and handles supplements on line items the adjuster missed.
- Step 04
Authorize, then the deposit applies
Jobs over $2,000 take a 50 percent deposit at authorization, and jobs over $10,000 take a further 25 percent when parts land. OCRV Center orders nothing before you authorize it.
- Step 05
The work
Work proceeds in the order that keeps structural and moisture issues from being sealed behind new finishes.
- Step 06
Pickup
Final balance is due at pickup. Card payments over $1,000 carry a 3.5 percent surcharge, which passes through the merchant fee rather than burying it in the labor rate.
Common questions
What is included in the onboard systems program at OCRV Center?
Everything that runs when the coach is parked. Power, LP, climate, water and appliances, diagnosed in shop with the vehicle on shore power and a full tank. The program covers 23 scopes: house battery replacement, inverter and charger, generator service, transfer switch and shore power, solar installation, antenna and starlink install, camera installation, lp system service, detector replacement, furnace service, water heater service, hydronic heat service, air conditioner replacement, ventilation repair, refrigerator service, cooktop and microwave, washer and dryer install, fresh water plumbing, black and gray tank repair, macerator pump, toilet replacement, shower pan replacement, faucet and fixture. All of it happens in shop.
How long does onboard systems work usually take in Whittier?
Labor bands across this program run from a few hours to several hundred. Parts availability drives the calendar more than labor does, and special order parts require a full non refundable deposit at the time of order, so the schedule is set once parts are confirmed.
Which vehicle is it?
The same scope prices differently by coach class, because the wall stack and the access are different on each.
Scope boundary
What this shop does not take
No mobile service. Every job happens at the facility.
No roadside assistance and no on site evaluation.
No engine rebuild and no internal engine machining.
No transmission rebuild and no drivetrain overhaul.
No DOT inspection and no DOT certification.
No emission testing and no emission certification.
No telematics installation and no fleet software.
No fleet consulting and no driver training programs.
Everything above is work OCRV Center declines rather than work it performs poorly. The facility is a body, paint, structural and onboard systems shop, and it is an in shop operation.
Bring it in
Insurance walk ins are welcome. The teardown hour is priced at $210 and credited against an authorized repair, so the evaluation is not a cost you lose if the work proceeds.
23281 La Palma Ave, Yorba Linda, CA 92887. Monday to Friday 8:00 AM to 5:00 PM, Saturday 9:30 AM to 3:00 PM.